Top-rated independent heating and cooling across Orange County and Southern California
Duct Replacement
Duct replacement means pulling out the old supply and return ductwork in your attic or crawlspace and installing new, correctly sized runs, sealed and supported the way they should be. Homeowners across Arizona, California and Nevada need it when ducts are crushed, torn open, sagging off boots, full of dust, or so leaky that half the cooling never reaches the room. If back bedrooms stay hot while the hallway is cold, call us and we will inspect the system and tell you what we find.
Call (888) 414-3292- Real people on the phone
- 7 days a week
- Quote in writing before any work
Taking calls until 5:00 PM PT
What the job involves
We start in the attic or under the house with a light and a camera, tracing every run from the plenum to each register. Then we remove the failed duct, cut and hang new flex or sheet metal on proper straps, seal every connection at the boots and plenum, and rebuild the return where it is choking the blower. Registers get reset and the whole system gets checked with the air on. Most single-system homes are done in a day or two, depending on access.
What we check and install
Before anything comes out we measure what the system actually needs, because undersized returns are the most common problem we find in stucco tract homes and coastal condos. We look at run lengths, sharp bends, the condition of the insulation, and whether the plenum was ever sealed. New work gets right-sized trunks, smoother turns, insulated flex or metal, and sealed boots at the ceiling. Where the return is starved we add or enlarge it so the blower is not fighting the house.
How we decide replacement is the right call
Patching wins when the damage is one torn run or a boot that pulled loose. Replacement wins when the duct is old and brittle, when several runs are crushed or disconnected, when rodents have been through it, or when the original layout was too small from the start. We tell you which one you are looking at and why, with photos from the attic. If a repair will hold, we repair it. We are not going to sell you a system you do not need.
The same on every visit
Written quote before any work
Covering 148 cities across Arizona, California, Nevada.A real person answers
Open 7 days, 8:00 AM to 5:00 PM PT.Independent of every manufacturer
Carrier, Trane, Lennox, Goodman and more. We are not an authorized dealer for any of them.Duct Replacement — quick answers
Will new ducts fix a room that never gets cool?
Often yes, if the cause is a disconnected run, a crushed elbow, or a duct too small for that room. We confirm the cause first, because the problem can also be a weak blower or a starved return.
Do I have to replace the whole system of ducts at once?
No. We can replace the worst runs and the return, then stage the rest. Doing the plenum and returns first usually gives the biggest change in how the house feels.
How long does duct replacement take?
Most homes take one to two days. Tight attics, two systems, or a full return rebuild can add time. We give you a schedule before we start so you can plan around it.
How it works
- Step 1
Tell us the symptom
Call or fill in the quote form with what you notice. Warm air, no air, short cycling, a smell, a noise. Details like when it started help us bring the right parts on the first visit.
- Step 2
We diagnose on site
A technician checks the thermostat, the electrical side, refrigerant performance, airflow and the return sizing. We test rather than guess, then explain what failed and why in plain language before any work starts.
- Step 3
Repair and verify
We make the repair, then measure temperatures and airflow at the vents to confirm the system holds. If a duct or return is starving the equipment, we tell you what it would take to fix it.
- A real person answers
- Open 7 days
- Written quote before work starts
Why homeowners call us
- We know stucco tract homesMuch of the housing we service was built fast with returns too small for the tonnage installed. That single duct in the hallway explains a lot of weak airflow complaints, and we look at it before we sell you equipment.
- Marine mornings, inland afternoonsCoastal condos fight humidity and salt air, while inland homes run long afternoon cycles in triple digits. Same system, different failure patterns. We set expectations for the climate your house actually sits in.
- Diagnosis you can followYou get told which part failed, what it does and what happens if it waits. No hurry, no scare talk. If the honest answer is that the system has a few seasons left, we say that.
- Repair before replacementMost calls end in a repair, not a new system. We quote replacement only when a repair will not hold or the cost stops making sense, and we explain the reasoning either way.
- All major brands, gas & electricFrom Carrier and Trane to Lennox, Goodman, Rheem and Bryant, serviced independently.
- Straight answersWhen a replacement beats a repair, we tell you, sometimes before we roll a truck.
Duct Replacement
Ready to book duct replacement?
Describe the system and your ZIP. The written quote comes before any work.
- A real person answers
- Open 7 days
- Written quotes
- All major brands
- Gas & electric
Rather not call? Get a free quote →